Q:How the concrete mixer works

The concrete mixer can be divided into two categories: self-fall and strong. Self-falling concrete mixer is suitable for mixing plastic concrete. The stirring effect of a strong mixer is stronger than that of the falling mixer, which is suitable for mixing hard concrete and lightweight aggregate concrete. A concrete mixer is a machine that stirs a certain mix of sand, stone, cement and water into a uniform quality concrete that meets the quality requirements. The concrete mixer can be divided into two categories: self-fall and strong.

Q:The safe distance of the concrete mixer

Different devices have different requirements. But the principle is, as far as possible little, and can't always wall during operation. Therefore, maintenance convenience, give attention to two or morethings is good with 3 -- 5 mm, the thickness of the maintenance when the replacement is a flat screwdriver

Q:Can you stir the mortar in a concrete mixer?

The blender is completely whipping the mortar. no problem，thank you

Q:The difference between concrete mixer and concrete mixer

Concrete mixing equipment is divided into concrete mixers and concrete mixers. Concrete mixing stations are also made of mixers. The concrete mixer is divided into three kinds of drum mixer, double cone and double cone. Concrete mixing stations are divided into engineering stations and commercial mixing stations and simple concrete mixing stations.

Q:How to safely use concrete mixer

A concrete mixer is a machine that mixes cement, gravel and water into concrete mixtures. It consists mainly of mixing, loading and unloading mechanism, water supply system, original motive, transmission mechanism, frame and supporting device. Operating procedures Before stirring, the car should be run in an empty car. Adjust the timing of the relay according to the stirring time. Water moistening the mixing bowl and the blade and the ground. The process, such as electrical or mechanical fault, should be discharged from the part of the mixing material, lighten the load, remove the fault and then drive again. When operating, the operation should be checked regularly to prevent safety accidents such as electrocution and mechanical injury. Finish the experiment, turn off the power supply, clean the mixing drum and the ground and clean up the cleaning.

Q:How many cubic meters of concrete is mixed with concrete mixer?

The 1000 type 1 square 2000 type 2 square 3000 3 square

Q:What are the pros and cons of a concrete mixer?

The noise is very large when mixing and feed, the installation is more trouble, the use of the dust is very large, the accident, the concrete mixing and the uniform time is not easy to control

Q:Operation procedure of concrete mixer

Before stirring, the car should be run in an empty car. Adjust the timing of the relay according to the stirring time. Water moistening the mixing bowl and the blade and the ground. The process, such as electrical or mechanical fault, should be discharged from the part of the mixing material, lighten the load, remove the fault and then drive again. When operating, the operation should be checked regularly to prevent safety accidents such as electrocution and mechanical injury. Finish the experiment, turn off the power supply, clean the mixing drum and the ground and clean up the cleaning.

Q:250 litres of the blender once made concrete

A concrete is a cubic meters, 250 litres of mixer can only every time out two-thirds of that which is around 170 litres, more easy to stir or uneven, wear a blender.

Q:How is the concrete mixer cleaned

When the blender is finished, rinse the water immediately, but you can't wash it if you don't clean it immediately