Detailed Product Description of HMBP-ST60 Modular Concrete Batching Plant
Modular structure, easy to transport, install and maintain.
Computer auto control mode, easy operation, high accuracy ensure
Main Equipment Composition of HMBP-ST60 Modular Concrete Batching Plant
1. Aggregate Supply
--- Gravel & Sand Supply Hopper / Aggregate Weighing Belt Conveyor / Slanting Belt Conveyor
2. Cement Supply
--- Weighing Screw Feeder / Cement Weighing Bin / Cement Weighing Valve
3. Water Supply
--- Water Pump / Water Piping / Water Weighing Bin / Water Weighing Valve
4. A.D Supply
--- A.D Pump / A.D Piping / A.D Weighing Bin / A.D Weighing Valve
--- Discharging Mixer / Concrete Chute
6. Main Frame
--- Main Frame (Trailer ) / Cabin
7. Air Supply Unit
--- Air Compressor / Air Piping
8. Power Supply
--- Power Panel / Fully Automatic Computer Panel / Supper Printer / Electric Wiring
- Q:What is the difference between a concrete mixer and a mortar mixer
- In power, power, and volume, concrete mixers search large
- Q:How long will it take for a concrete mixer to beat ten square?
- The first set of 10 square is 120, and the first set of 2 squares is calculated from the above, and the time is saved by 4 minutes in 4 minutes, the average of 15 minutes is calculated by C50 high performance concrete. If it's a C20 no water reducer, just five minutes!
- Q:What is the JZ250 concrete mixer
- Jzc250 introduction 1) the discharging capacity of 250 l 2) feed capacity of 350l 3) productivity 7-10 m3 / h 4) mixer cylinder speed 17 r/min 5) the maximum size of the aggregates is 60mm 6) the accuracy of water accuracy is less than 2% error 7) stir the motor 4 kw 8) pump motor 0.55 kw 9) maximum drag speed 115km/h 10) dimensions (x width x height) 2226x1990x2750mm 11) the weight 1950 kg1650kg1500kg
- Q:How to safely use concrete mixer
- A concrete mixer is a machine that mixes cement, gravel and water into concrete mixtures. It consists mainly of mixing, loading and unloading mechanism, water supply system, original motive, transmission mechanism, frame and supporting device. Operating procedures Before stirring, the car should be run in an empty car. Adjust the timing of the relay according to the stirring time. Water moistening the mixing bowl and the blade and the ground. The process, such as electrical or mechanical fault, should be discharged from the part of the mixing material, lighten the load, remove the fault and then drive again. When operating, the operation should be checked regularly to prevent safety accidents such as electrocution and mechanical injury. Finish the experiment, turn off the power supply, clean the mixing drum and the ground and clean up the cleaning.
- Q:Common type of concrete mixer
- The common concrete mixer is divided into two kinds: self-falling concrete mixer and strong concrete mixer.
- Q:Where can a concrete mixer be used?
- Construction sites, Bridges, roads and so on are indispensable
- Q:The safe distance of the concrete mixer
- Different devices have different requirements. But the principle is, as far as possible little, and can't always wall during operation. Therefore, maintenance convenience, give attention to two or morethings is good with 3 -- 5 mm, the thickness of the maintenance when the replacement is a flat screwdriver
- Q:How the concrete mixer works
- The concrete mixer can be divided into two categories: self-fall and strong. Self-falling concrete mixer is suitable for mixing plastic concrete. The stirring effect of a strong mixer is stronger than that of the falling mixer, which is suitable for mixing hard concrete and lightweight aggregate concrete. A concrete mixer is a machine that stirs a certain mix of sand, stone, cement and water into a uniform quality concrete that meets the quality requirements. The concrete mixer can be divided into two categories: self-fall and strong.
- Q:How many tiles are in the concrete mixer on the site
- The type of concrete mixer on the site is different, the power is different. The type of concrete mixer is normally divided by the amount of material, such as the JS500, which indicates the amount of material 500L. A concrete mixer usually has three electric motors: stirring motor, winding motor, pump motor. The following is the power of the blender: The amount of material is 350L, general power of 19.55 KW. The output is 500L, the mixer power is 18.5 KW, the hoist power 5.5 KW, the power of the pump is 750W, the total power is 24.75 KW. Output of 750L, mixer power 30KW, hoist power 7.5 KW, pump power 1.1 KW, total power 38.6 KW; Output 1000L, mixer power 37KW, hoist power 11KW, pump power 3KW, total power 51KW; Output of 1500L, mixer power 45KW, hoist power 18.5 KW, water pump power 3KW, total power 66.5 KW. The output is 2000L, the machine power is 75KW, the power of the hoist is 22KW, the power of the pump is 4KW, the total power is 101KW.
- Q:How many cubic meters of concrete is mixed with concrete mixer?
- Js5001/750/1000/1000/1500/2000/3000/3000 concrete mixers and concrete mixers Depending on the model, you can determine a 0.75 square plate of 0.5 square 750 for the 500 The smallest drum mixer is 0.3 square
"High-Quality Products, Efficient Service, Integrity and Innovation" is our eternal pursuit. . It's always our hope to establish long and stable business relationship with you to reach Win-Win situation. We welcome new and old customers from all walks of life to contact us for future business relationships and achieving mutual success!
1. Manufacturer Overview
|Annual Output Value
||US$1 Million - US$2.5 Million
2. Manufacturer Certificates
|a) Certification Name
3. Manufacturer Capability
||31% - 40%
|No.of Employees in Trade Department
||English, Chinese, Spanish, Portuguese, Arabic, French, Russian, Hindi
||Above 100,000 square meters
|No. of Production Lines
||OEM Service Offered
|Product Price Range
||Low and/or Average