Electric Forklift Truck CE Approval 1.6 Tons (CDD16)
Model: Cqdm12/15:Power Souce: AC
Loading Capacity: 1200kg/1500kg:Lifting Height: 1400-4000mm
Operate Type: Standing:Overall Length:2440mm/2896mm
Turning Radius :1596/2040mm:Origin; China
Packing:Packing Type: 1PC/Pallet
Production Capacity:200 Piece/Pieces Per Month
Configuration And Preformance
1,Fork lift, double oil cylinder more smoothly;
2,Electro-hydraulic integrated control,multi-function handle;
3,Electronic power steering system,light and low noise;
4,Two-way magnetic valve,three droup speed mode.
5,AC Driving system.no carbon brush,maintenance free;
6,USA CURTIS driving controller;
7,Electromagnetic,regnerative braking system;
8,Automatic lifting limit,proximity switch ,long life;
Curve automatic deceleration devices,more safe;
Goods high position,vehicle automatic deceleration
Slepless speed control system,safe and quiet
Controller with multiple automatic protection
Emergency reversing device/emergency brake switch
| Model|| CQDM12/15|
|Mast Type||2-Stage STD|
|Operator type||Stand on|
Driving wheel/balance wheels/Bearing wheels
|Max extend height||mm|
|Max extend height||mm|
|forks adjust width||mm||200-755|
|fork tilt angle(forward/backward)||z/v °||3.0/5|
|Min.right angle stacking aisle width,800x1200 pallet(1200 side)||mm|| 3023/3456|
|Min.right angle stacking aisle width,1000x1200 pallet(1000 side)||mm||3044/3472|
|Travel speed loaded/unloaded||Km/h||5.0/5.5|
|Lift speed loaded/unloaded||mm/s||130/230|
|Lowering speed loaded/unloaded||mm/s||130/230|
|Drive motor/Lift motor/Steering motor||kw||AC1.5/DC3.0/DC0.15|
|Truck weightt(with battery)||kg||2100|
- Q:Whether there is a national standard or standard for the charging of forklift truck in the factory
- The battery charging or storage site should be kept well ventilated, with ventilation and ventilation facilities to prevent the explosion of combustible gas. Smoking in the charging room of the forklift truck is prohibited from smoking. No phone calls in the rechargeroom, such as phone calls to the charging room. 3, as the electrolyte in the battery is a mixture of sulfuric acid and aqueous solution, toxic and corrosive, so when to battery charging and near its must wear overalls and protective glasses. If your skin or eyes are stained with electrolyte, rinse immediately with water and if you have an electrolyte in your eyes, turn to your doctor immediately
- Q:Can a forklift get on the highway?
- Forklift is special vehicles, motor vehicles within the factory, the according to the regulation on administration of motor vehicle safety inside the plant, plant of motor vehicles, refers to an enterprise which is limited to within the scope of the factory (including production area such as docks, freight yard or construction site) and the operation of motor vehicles. So forklifts are not allowed to go on the road.
- Q:But they had heard jac forklift, now out a new model seems like three years warranty, feeling pretty good, now dare to do three years warranty of forklift jianghuai should be the first.
- The joint hang-fork is the longest year, some of which are 3 months and 6 months, hydraulic parts and bridge transmission for a year, or 2, 000 hours; The engine is half a year, 1000 hours. Most of the other manufacturers are guaranteed for six mon
- Q:What if the forklift oil is burned and the oil is burned
- First open the hood, and pull out the distributor of the central high tension line, from the cylinder block there is 6 or 7 mm, switch on the ignition switch, turn the crankshaft, view the high tension line to produce edm. If there is no spark, there is a fault in the low voltage circuit with short circuit, broken circuit or ignition coil and central high voltage line. Interchangeably disconnecting, closing contact, observing the meter pointer reading. If the current meter instructs the discharge 3 ~ 5A and the intermittent oscillations, the low voltage circuit is good, the fault occurs in the high voltage circuit. If the current meter pointer does not oscillate, it indicates that the low voltage circuit is broken. If discharge of large current of electric current meter, indicates that there is an iron failure in low voltage circuit. If the spark is too strong, it creates a blue and white spark. The low voltage circuit and the ignition coil are good, the fault is in the distributor and the spark plug high voltage circuit. From the top to remove the high tension line head, spark plug rocking-turn crankshaft to the body tries to fire, such as no fire should check the distributor rotor, distributor cap, and whether high subsection line leakage, is when the spark ignition timing shall be checked and the performance of the spark plug.
- Q:What insurance does a forklift driver need?
- Thanks to the analysis above, I don't know if there is a definite answer to these two questions, does the state or the relevant departments have mandatory regulations and requirements?
- Q:What do you need to do to get a forklift license from the quality technology supervision bureau
- The driver of forklift has written test and practice exam, which is divided into two major categories, the pile test and the road test. There are different ways of testing in the area. Some areas are the actual driving forklifts, the actual operation of driving forklifts, the inspection of the rods, the line, the start, the fork, etc. This reflects the management of a region.
- Q:Where is the forklift certificate in which department?
- First before take an examination of forklift license to drive a forklift, through formal training institutions for training, and reported by the training institutions materials by the municipal bureau of safety personnel assessment of drivers, can be obtained by theoretical and practical operation test forklift license.
- Q:What do you mean by the center spacing of the load on an electric forklift?
- For a balanced electric forklift or a battery-powered stacking, a little extra weight or the center of mass of the cargo is not a problem in front of the load center. I said a little bit. But for stacker, because be stacker itself weight is light, so if you exceed and load or the goods promotion center migration, is likely to cause instability and collapse! So you need extra attention when you're using a stack. In particular, a semi-electric truck and a manual hydraulic stack. Because the body itself weighs less than two hundred kilograms, it would be too dangerous to raise a ton or two tons of goods, plus a central shift.
- Q:Can a forklift drive into an elevator?
- My friend, although it has happened, I still want to tell you that it's ok if you do the right thing. I don't believe that will be difficult for you. Remember to study forklift and elevator operation mode. This way, you have the bottom, more the next time convenient express
- Q:What is the cause of my forklift
- There was no oil tank; Come on Oil pumps do not pump oil; Replace the oil transfer pump 3, pump plunger wear; Replace the pump plunger 4, the oil supply time is not right; Adjust the oil supply system 5, disordered; Adjust the gas parameters 6, the battery is dead. Replace the battery 7, the connection line is in bad contact; Reconnect the 8, starting motive failure; Professional manufacturer's repair
1. Manufacturer Overview
|Annual Output Value
2. Manufacturer Certificates
|a) Certification Name
3. Manufacturer Capability
|No.of Employees in Trade Department
|No. of Production Lines
|Product Price Range